DYMBOX, Smoke generator, generator for smoking, 4 smoke
Shipping time to USA is about 10 days… Shipping time to UE is about 3-5 days… Shipping to Norway is about 3 weeks I offer to sell highly efficient large smoke generator DYMBOX to the smokehouse. GENERATOR is 40 cm high. It’s made of stainless steel fi 90 mm with a thickness of 2.0 mm. Capacity 2,32 liters. You can use this smoke generator for cold smoke from 3 to 6 hours on one refill, depending on pump performance settings (with settings for minimum pump and a pressed wooden chips small size of much longer). It is powered by a powerful pump, which is even smoke in large smoke houses above 1000 l. Also suitable for grills with lids (electric or gas ). It is powered by wooden chips different flavours and granulation ( its depend on You). The advantage of this type of generator is that the smoker need not much wooden chips. Unlike similar generators, this one does not have a permanently welded components that prevent cleaning. It is completely demountable, so it can be easily cleaned. The length of the tube entering to the smoker ( Smoke house) is 12 cm. For Smokers warm or hot will be enough to insert into the smoking chamber heater with thermostat or for example, electric grill, or most ordinary electric cooker with temperature control, then we have a professional smokehouses, You do not have to watch, nothing burnt. The kit offered SMOKE GENERATOR includes: – Smoke Generator. – Pump. – The power cable with a length. 1.5m high temperature resistant. – The smoking chips 1 kg per half day are enough smoking. – Lighter. You can buy wood chips on our online store dymbox.com DYMBOX device has been designed and developed to produces smoke for smoke chambers in the smokehouses as well as for barbeques during amateur smoking. For the device to work you only need to add fuel to smoking chamber. You can refuel it at any time without need to stop the generator. You only need to add woodchips, briquette or pellets. Smoke volume is adjusted by increasing or decreasing air pump efficiency. How it works: Our smoke generator is powered by solid fuel: smoking woodchips, pellets or briquette. Burning process takes place just above the smoking pipe in a hopper, across its entire diameter. Smoke produced during burning process through pump with proper efficiency is drawn down to hole in the smoking pipe and is then pumped into smoking chamber. The advantage of this solution is the fact that: 1. Fuel in our generator does not hang, but falls down loosely and freely during the burning process. Unlike to other generators, where smoking takes place well below smoking pipe and woodchips (that should burn) are blocked by smoking pipe, our generator has a grate above the smoking pipe. In Dymbox smoke generator there is no need to push the fuel as it does not get stuck. 2. By implementing such a solution, smoke produced from burning has no contact with pure fuel which is not yet involved in the burning process thus it does not saturate pure woodchips with tarry substances and dampness as it happens in similar smoke generators available on the market. They have low grate, where smoke before entering into the smoking chamber penetrates a few-centimetre-layer of fuel which is not yet involved in burning process and contaminates and dampens it. Thus dirty, grime and damp woodchips smoke our meat? 3. In the device, below side air-draw nozzles, there is an ash-pit for big amount of ash what enables to smoke longer (for several hours) without need to empty it. The generator can be fed with wood chips ranging in size from 2 mm to 12 mm. Using this size chips were made studies of PAHs (the content of harmful compounds including benzo(a)pyrene). Industrial design protected by the Polish Patent Office. Reproduction prohibited. Number PL 21072 31.12.2014 r.